176 Solar Egg Incubator and Hatcher

Incubator farmers in the summer in addition to strengthening the ventilation of the chicken house, must take other heat prevention measures. After continuous exploration and practice, there are a variety of measures to solve the problem of heat prevention and cooling in the chicken house, all of which have a certain effect of heat prevention and cooling, but practice has proved that water curtain evaporation cooling is the most effective way to control the temperature of the chicken house in summer.

In the case of the same humidity outside, the higher the temperature of the 176 Solar Egg Incubator and Hatcher, the greater the cooling range after cooling through the water curtain. In the case of high humidity, no matter what the external temperature is, the cooling effect is limited. When the humidity is 80%, the temperature can be reduced by 2.7℃ when the external temperature is 40.5℃; when the external temperature is 26.5℃, the cooling range is 2.0℃; in the case of low humidity, no matter what the external temperature is, the cooling effect is obvious; when the external temperature is 40.5℃, the temperature can be reduced by 14.2℃ when the humidity is 30%. When the external temperature is 26.5 ° C, the cooling range is 9 ° C, so the external relative humidity is the restriction of the cooling effect of the curtain, and the lower the external humidity, the more obvious the cooling effect.

In winter chicken coops raised with 176 solar egg incubator and hatcher, while paying attention to insulation, in order to ensure normal environmental conditions inside the coop, the exhaust cannot be completely turned off even when the temperature is lower than the set temperature. Instead, 176 solar egg incubator and hatcher controlled by a timer should be used to minimize ventilation in the coop.

However, the following four necessary conditions should be met when using the minimum ventilation. A chicken coop that is enclosed, insulated, and has no air leakage; The cold air outside the house cannot directly blow onto the chicken body; Determine the correct ventilation rate based on the age of the chicken flock; The ventilation switch is controlled by a five minute timer, or a complete switching cycle is controlled by a controller that is no longer than five minutes, with an accuracy of less than one minute.

In winter chicken coop temperature statistics, the temperature inside the 10 minute cycle is significantly higher than that of the 3 minute cycle. However, if a cycle is too long, the temperature fluctuation inside the coop will be relatively large. If the cycle is too short, although the temperature fluctuation will decrease, the air circulation inside the coop is poor and the air quality inside the coop is not good in one cycle. After comparing the three different set cycle periods of 3, 5, and 10 minutes, and considering the above two factors comprehensively, A 5-minute cycle can provide good air quality and temperature consistency.

Hot Tags: 176 solar egg incubator and hatcher, China 176 solar egg incubator and hatcher manufacturers, suppliers, factory, quail laying cages, 3 Levels 4 Door Chicken Layer Cage, poultry incubator machine, 528 Solar Egg Incubator and Hatcher, solar poultry incubator, 500kg Crusher Mixer Machine